The average cost of a Carrier inducer motor replacement is between $800-$1800.
How much is an inducer for a Carrier furnace?
The average cost of a Carrier inducer motor replacement is between $800-$1800.
How do I know if my furnace inducer motor is bad?
One of the first indications of a bad draft inducer motor is likely to be the sound it makes. A failing inducer motor may create a noise shortly after a heating cycle begins. This could be a tapping noise, or a humming or whirring sound.
How long does a furnace inducer motor last?
Let’s also not forget what and where the device gets installed. Is it part of a home heating system or on a commercial property furnace system? Even though the manufacturer states their blower motor will last two decades, we advise all clients to expect a 10-20-year life span due to age, use, and proactive maintenance.
How much does a Carrier motor cost?
How much does a Carrier air conditioner fan motor cost? A Carrier air conditioner fan motor can range from $80 to $220.
Why is my inducer motor noise?
A draft inducer (or vent blower) is the most common problem on a gas furnace or boiler to cause a noticeable noise. … The small motor mounted within the housing can begin to make noise when there is buildup on the wheel (such as sulfur or creosote) or when the motor is close to the end of its usable life.
How much does a furnace blower motor cost to replace?
An HVAC blower motor replacement costs an average of $450 but anywhere from $150 to $2,000 to replace. It doesn’t matter if you have a gas furnace, electric or heat pump, they all use an air handler blower motor to push the air throughout your home’s ducts.
What causes inducer motor failure?
Most inducer motors failures are simply attributed to the older age of the furnace. In most cases, the internal bearings wear out and since the unit is a sealed unit, there is no way to repair the original motor. Instead the unit is simply replaced with a new one.
What does an inducer do on a furnace?
By turning on before your furnace ignites its burners, the draft inducer is able to clear out any combustion gases that might be lingering in the heat exchanger from the previous heating cycle. Those gases are pushed into your system’s flue pipes and vented out of your home.
Should I replace a 15 year old furnace?
Unfortunately, even the highest quality heating systems don’t last forever. According to the U.S. Department of Energy, a furnace should last 15-30 years before you’ll need a replacement. … Replace: Any system over 15 years old is prone to frequent and expensive repairs and may need to be replaced.
How much does a carrier blower motor cost?
Be sure to check before you hire a serviceman. On average, a Carrier blower motor replacement costs $150-$500. If your furnace needs a new squirrel cage fan, also known as a blower wheel, then you can expect to pay a bit more, about $250-$600 total.
How long do AC motors last?
The average lifespan of an AC fan motor is about 12 years. An AC fan motor can last more than 12 years if it’s kept clean and cooled as needed. On the other hand, without annual maintenance checkups, your fan motor may only survive between one and three years.
How long is carrier blower motor warranty?
Carrier Air Conditioner Warranty
Carrier offers a 10-year parts limited warranty for Infinity, Performance, and Comfort series air conditioners that utilize Puron refrigerant. For the warranty to be valid, the owner must meet Carrier AC warranty conditions: The unit must have been installed on or after January 1, 2009.
How do you lubricate a furnace inducer motor?
Spray a thin film of silicone lubricant on the motor shaft where it enters the blower wheel bearings. Reinstall the service panel, then turn on the circuit breaker to power the furnace.